River Sand by Quarry Dust Waste In Concrete For Sustainability. International Journal of Scientific & Engineering Research Volume 4, Issue 5, May-2013 ISSN 2229-5518 [6]. J. Karthick1, T.Rama2, N.Mani Bharathi3, An Experimental Study on Usage Of Quarry Rock Dust As Partial Replacement for Sand in Concrete. [7].
5 0 th 50th INDIAN GEOTECHNICAL CONFERENCE 17 th– 19 DECEMBER 2015, Pune, Maharashtra, India Venue: College of Engineering (Estd. 1854), Pune, India SUITABILITY OF WASTE PLASTIC AND QUARRY DUST IN IMPROVING THE STRENGTH CHARACTERISTICS OF SUBGRADE SOIL
Stone dust is a kind of solid waste material that is generated from stone crushing industry which is abundantly available. It is estimated that each crusher unit produce 15%-20% stone dust. Disposal of such wastes poses lots of geoenvironmental problems such as landfill disposal problems, health and environmental hazards. The best way to eliminate these problems is to make use such waste.
The use of by-product materials to improve the soil properties varies with economic, environmental and technical points. In this study, the solid wastes such as fly ash, copper slag, saw dust ash, paper sludge, quarry dust, stone dust, steel slag and brick dust are utilized as cementitious material to stabilization the Black cotton soil. II.
3.4 Quarry Dust The quarry dust used for this investigation work is obtained from the quarry near tindivanam in Tamil Nadu. The quarry dust passing through 4.75 mm retained on 150 micron IS sieves are taken. Specific gravity of 2.617 and fineness modulus of 2.706 has been used. 3.5 Silica Fume The specific gravity of silica fume is 2.2.
Study of Engineering Properties of Expansive Soil Stabilized with Quarry Dust and Fly Ash. Pages 75-83. Bhoi, Manas Kumar (et al.) Preview Buy Chapter 25,95 ... Kolkata. Pages 243-253. Kumar, Sajjan (et al.) Preview Buy Chapter 25,95 ...
An Experimental Investigation on Properties of Concrete by Partial Replacement of Cement with GGBS and Fine Aggregate with Quarry Dust Dr. D. V. Prasada Rao1, C. S. Mallikarjuna2 1Professor, Department of Civil Engineering, Sri Venkateswara University College of Engineering…
characteristics of Quarry Dust Concrete (QDC) containing 0% to 30% of fly ash. Based on the test results, it can be concluded that combined use of quarry dust and fly ash can be shown improved strength in concrete and also preserve the environment. Keywords: - Fly Ash, Properties, Quarry Dust, Strength I. INTRODUCTION
kolkata open cast mining electrical equipment. kolkata dimensions of cone crusher cancave. As a leading global manufacturer of crushing equipment, milling equipment,dressing equipment,drying equipment and briquette equipment etc. we offer advanced, rational solutions for any size-reduction requirements, including quarry, aggregate, grinding production and complete plant plan.
5) QUARRY DUST: The quarry dust is the by-product which is formed in the processing of the granite stones which broken downs into the coarse aggregates of different sizes. The physical and chemical properties are listed in Table 1 and Table 2 Table 1: Physical Properties of Quarry dust Property Natural Sand Quarry Dust Test Methods
It is clear from the graph that the liquid limit is of permeability (k) and the percentage of the quarry 123 424 Geotech Geol Eng (2012) 30:419–430 Table 3 Geotechnical properties of lithomargic clay stabilized with quarry dust Sl. no. Parameter Percentage of quarry dust added 0% 10% 20% 30% 40% 50% 1 Clay size (%) 12 11 9 8 5 3 2 Silt size ...
Effects of Higher Percentage of Stone Dust Used as a Fine Aggregate in Concrete and Variation of Strength due to the Variation of Cement Content and W/C Ratio . Bikram Paul1, Kushal Ghosh 2 and Partha Ghosh 3. 1PG Student, 2PhD Student, 3Associate Professor . Department of Construction Engineering, Jadavpur University, Kolkata, West Bengal, India
PROPERTIES REQUIRED FOR MAKING OF FLY ASH BRICK MD MAINUDDIN Assistant Professor of Civil Engineering Dream Institute of Technology, Kolkata, India ... Gypsum, Quarry dust, Sand, Cement, Material ...
Experimental Investigation on Quarry Dust and Recycled Aggregates in Concrete 3 2.2. Fine Aggregate and Quarry Dust Good Quality River sand, free from silt other impurities were used in this study. Sand passing through 4.75 mm has to be used in this experimental work. Quarry dusts are occupied in rest of Thiruvakarai Quarry. Get More
Quarry dust mixes. Table 3.3 CBR Value for Soil +Quarry Dust Mixes Soil+Quarry dust (%) CBR (%) Soaked 100+0 1.82 90+10 2.62 80+20 3.03 70+30 3.66 60+40 4.19 50+50 3.55 4. CONCLUSIONS The experiment conducted to study the effect of Quarry dust addition on …
IMPACT OF QUARRY DUST AND FLY ASH ON THE FRESH AND HARDENED PROPERTIES OF SELF COMPACTING CONCRETE Abdul Razak.B.H1, Madhukeshwara.J.E2 1Assistant Professor, Department of Civil Engineering, JSS Academy of Technical Education, Bengaluru, India email 2 Structural Engineer, Hyder Consultants, Bangalore, India
Quarry dust The basic tests on quarry dust were conducted as per IS-383-1987 and its specific gravity was around 1.95. Wet sieving of quarry dust through a 90 micron sieve was found to be 78% and the corresponding bulking value of quarry dust was 34.13%. Coarse aggregate replacement of sand with quarry dust of mortar cube (C
C thermal properties (thermal expansion, conductivity), and C in situ stresses. This second set of lecture notes focuses on physical properties such as weathering potential, slaking potential, swelling potential, hardness, abrasiveness, and other properties such as porosity, density, water content, etc. Most of those properties are intact rock ...
of quarry dust on the engineering properties of lateritic soil. The underlying objectives are to: 1. Investigate the natural engineering properties of lateritic soil samples. 2. Study the effort of the lateritic soil on the quarry dust. 3. Determine the feasibility of using quarry dust as lateristic soil stabilize. 4.
At the East of Thailand, a shortage of river sand for producing concrete has frequently occurred while the large amounts of quarry dusts are being produced as by-products of stone crushers in many stone quarries. Then, the quarry waste from 12 stone quarries (in Rayong and Chonburi province) was taken to investigate the engineering properties as fine aggregate for concrete.
physical and chemical properties of quarry dust with respect to requirements of codal provision which are satis ed. e % replacement of sand with quarry dust gives better results in terms of compressive strength studies. 3. Tests on Quarry Dust Quarry dust is …
In this study they have concluded that soil improvement can be done using quarry dust which helps in enhancing engineering behavior or properties of soil with cost effectiveness. In another experimental study quarry dust is incorporated into fired clay bricks A A Kadir, M I H Hassan, N A Sarani, A S Abdul Rahim and N Ismail [10].
This research investigated the potential of cement stabilized shale quarry dust for possible use as road foundation material. From the results, the shale consists mainly of SiO2 (27.7–60.1%), Al2O3 (7.30–17.9%), CaO (3.91–32.3%) and LOI (4.93–18.8%). The shale quarry dust (SQD) in its natural state had an average liquid limit (LL) as 38%, plasticity index (PI) as 24% and …
The important properties such as index properties, compaction characteristics, shear strength parameters, CBR values, and consolidation characteristics were studied. The results obtained indicate that there is an improvement in almost all properties with the addition of quarry dust, thus making the soil suitable for road works and other projects.
Quarry dust is a by-product of rubble crusher units and is a commonly available material, due to the vast usage of crusher metal in the construction industry. This product can be used to improve engineering properties of high plasticity silty (MH) soils, in order to develop a cost effective method for highway sub-grade construction.
The optimum ratio of fly ash and billet scale, quarry dust and billet scale is found to be 1:1 since it showed the best performance with regard to mechanical properties. (6) Manufacture of bricks using a combination of billet scale, quarry dust and fly ash is feasible.
The quarry dust samples were oven-dried for one week before been measured to get the required proportions for each test. The quarry dust sizes of 0/4.75 mm via BS (British Standard) sieve size were used for the subsequent laboratory tests. According to the Cement and Concrete Institute, continuous grading usually facilitates compaction. For ...
b) Quarry dust c) Glass d) M-sand. Answer: b Clarification: Surkhi is pieces of burned clay, M-sand is manufactured sand, glass can be powdered and these form excellent substitutes for sand. Quarry dust has flaky grains and is not recommended to use in concrete or masonry works, though it can be used for low strength works. 10. The density of ...
In this study the properties of concrete with quarry dust as fine aggregate is studied to find out its suitability to replace river sand in structural concrete. Furthermore, use of fly ash with 30 ...
The cement and quarry dust are both suitable for general purpose concrete works. Table 1: Chemical Properties of cement and Quarry dust used Component CaO Al 2 O 3 SiO 2 Fe 2 O 3 SO 3 Cl MgO TiO 2 K 2 O LOI Cement 64.34 4.51 20.79 2.64 1.48 0.03 1.66 - 1.26 1.7 Quarry dust 2.43 16.72 65.66 3.92 - - 3.56 2.21 0.88 -
